finish carpentry Archives - Page 2 of 3

Ten gallons of sawdust later…

February 22, 2007

I finished cutting 208 feet of bolection moulding for the wainscotting in the bedroom reno and guess what? I needed 216 feet to complete the job, dammit! I knew I was cutting it close (literally) but I only had a couple of (expensive) red oak 1x8s left which I need for the wainscotting shelf. I’ll dig into my red oak scrap pile and cut the remainder this afternoon. Anyway, I was right. A bolection moulding a/k/a inset panel cap moulding a/k/a rabbeted panel moulding is just an inverted base cap profile with a rabbet. After my router bit quest, I

Bay window trim (almost) done.

February 12, 2007

Sheesh. Another “almost” cop out. The issue here isn’t woodworking but thermodynamics. The steam radiator that Richie from Sessa Plumbing installed is something called an “element”. An element works on the convection principle: as hot air rises off the element, it expands and exits through a grill at the top. This creates a low pressure area underneath which pulls in cold air from the floor through a grill at the bottom. An element radiator usually comes in a butt-ugly metal cabinet. It’s what that missing panel under the middle window needs to replicate. I’m gonna give you a private snapshot

It depends on what “almost” means…

February 12, 2007

I’ve been looking forward to this day for months. Almost all the trim, the doors, cabinets, etc are done! What’s “almost”? By “almost” I mean that the center of operations moves downstairs to my shop. The remainder of the trim work — the cabinet doors and drawers, the panels under the bay window, the stained glass window, the overhead closet doors and even the curved baseboard moulding for the closet corner have to be fabricated. I need my stationary power tools for this stuff. “Almost” also means that I need to make a decision about whether or not to incorporate

The Mystery of the Ducts To Nowhere

January 20, 2007

(Or “Why A Duct?”, with a tip o’ the hat to the Marx Bros) This house has ancient, single-pipe steam heating. From what I’ve been able to determine from digging in these walls over the past seven years is that it’s always had steam heating. Nothing interesting there. What’s baffling is why the house also has ancient metal air ducting buried inside the walls. I discovered this shortly after I moved here when I ripped down the basement ceiling and found three vertical ducts to nowhere. Over the past hundred years, various plumbers and electricians had used them for service

Another mini-milestone reached

December 28, 2006

Just like software development, I like to break big projects down into milestones and mini-milestones. Milestone Mini milestone Wall prep done Structural carpentry done Finish woodworking Wainscot east wall + outlets Window and door trim – large room Complete wainscot – large room Window trim and wainscot – ante room Construct and install dresser and cupboard – ante room Ahhhh… and here we are (check!) My next mini-milestone is the completion of all the woodworking in the hallway, followed by installation of the crown moulding over the windows, doors and this cabinet, followed by hanging of all the doors, followed

Bah, humbug

December 21, 2006

It looks like slow going at BrooklynRowHouse but you’ll have to take my word for it: trim like this takes a lotta time. I probably have 60 hours of woodworking just into this tiny ante room and it’s still far from done. So what’s the hold up? I won’t spend a lot of time talking about my “real world” obligations, but my two oldest clients, Children’s Health Fund and Operative.com, both hit me with a pile of work to complete before the end of the fiscal year, which is 12/31 in both cases. It’s SNAFU for consultants like me this

Face Frame 101

December 7, 2006

There’s a subculture in the carpentry world that one could call “wood nerds”. They passionately argue with each other over arcane topics like fish glue and lumber humidity, armed with canons of really impressive woodworking knowledge. I learn a lot from them but after a while it’s like listening to trekkie geeks debate the relative pulchritudes of Lt. Uhuru versus Seven of Nine. One of these contentious topics is “face frame” versus “32mm frameless” cabinet construction. Most traditional cabinets are face frame while “European style” cabinets are generally frameless, or boxes with full-width doors. Both work. That’s about the extent

Rule #1: don’t kill yourself

November 27, 2006

Work here has come to a halt for a little while. Several weeks ago I was working on our community dog run, shoveling wet wood chips like a teenager on dexadrine. I woke up the next morning with tendonitis in my right elbow. My next door neighbor is a chiropractor and told me to knock off the room renovation for two or three weeks to let it heal. I forged ahead as did my elbow pain. This morning I woke up feeling like I’d fractured the base of my thumb at the wrist. Back to Dr Joe, who reminded me

Hangover Eve

November 23, 2006

I’ve been working at a frantic pace on the master bedroom renovation the past couple of weeks, trying to get as much done before the official start of the holidays. That’s why my blog is so stale. It’s not just that the holidays are distracting but that some of my clients need to burn what’s left of their fiscal budgets before Q1. Somewhere in those precious few weeks I’ll also be on Nantucket to work on Karen’s place. I thought I’d start with the “cute doggy” shot. Anyway, the trim carpentry in the large room is almost done. I still

Al Bundy, Home Renovation

November 13, 2006

A few days ago, Jeannie from House In Progress referred a woman from a new ABC reality show to me. From the email it sounded like she was looking for folks who had gone way over their heads on a home improvement project and needed 911 from the professionals to bail them out. I told her that this was my fourth major construction project in 25 years and that I wasn’t (*harumph*) a rookie at this stuff. I politely declined. But the next day I wondered if I wasn’t exactly the sort of Al Bundy cartoon character she wanted. After

Category: finish carpentry